Hot selling mini concrete mixer trucks for sale from China
  • Hot selling mini concrete mixer trucks for sale from China

Hot selling mini concrete mixer trucks for sale from China

 From the car chassis, the mixing tube, transmission, water supply device, full power PTO, front and rear mixing tube bracket, part reducer, hydraulic transmission, access to material systems, control agencies

Hot selling mini concrete mixer trucks for sale from China Features and Benefits :

The composition of concrete mixer

From the car chassis, the mixing tube, transmission, water supply device, full power PTO, front and rear mixing tube bracket, part reducer, hydraulic transmission, access to material systems, control agencies. Due to technical bottlenecks, domestic mixer tank volume of 3m³-8m³ the use of domestic four pieces, four pieces of most of the imported parts used 8m³ more volume. Mixer: the two types of chassis, powertrain, hydraulic systems, racks, mixing tank, out equipment, water systems, steering system, ladder and other components. Stirred tank front end reducer coupling mounted in front of the rack on stage, supported by the rear end by roller mounted in the rack back two idler.

How small concrete mixer gear pump allowed to work Small concrete mixer gear pump Abnormal:

1, small concrete mixer suction pipe or suction line too long or thin; 2, concrete mixer truck suction flange seal is bad, there are air intake, oil seals into the air, bubbles, insufficient capacity suction strainer in the pipeline; 3, small concrete mixer hydraulic oil quality is poor, the high viscosity of the oil. Remedy: 1, remove concrete mixer truck blocked the dirt, change piping, pipe diameter increase; 2, smaller concrete mixer filter change, according to the provisions replace the hydraulic oil or hydraulic oil preheating; 3, the replacement of O-rings, tighten the flange screws, replace seals.

Small concrete mixer can not start  

1) concrete mixer poor compression - compression check, if necessary, to repair the engine, a small concrete mixer - mixer  2) Mixer oil pressure too high - oil spilled pressure valve or pump failure (causing the valve can not be closed) concrete mixer - mixer  3) concrete mixer truck ignition fault - check, when in need of repair.  4) three yuan catalytic device blocking small concrete mixer  5) small concrete mixer valve timing inappropriate - regular check valve, if necessary, corrected. Mixer  Second, the concrete mixer starting difficulties  1) mixer ignition system failure - the use of an oscilloscope to check the ignition system.  2) poor compression - compression check and repair the engine when needed.  3) mixer fuel pressure regulator, fuel pump - check fuel pressure and injector.  4) The oil-rich air-fuel ratio, injector, input speed rush failure - Check the fuel injector, for fault diagnosis. Turn catch is performed on the input voltage, resistance testing.  5) small concrete mixer lean air-fuel ratio, vacuum leak, fuel injector drum barrier - the inspection of imported vacuum leaks, fuel injectors. Mixer truck  Third, concrete mixer torque converter lockup clutch lock engine instability after  1) compressed air Port poor - Check the engine pressure, engine repair, if necessary.  2) concrete mixer spark plugs, ignition wires, ignition coil.  3) Throttle Position Sensor - Check sensor and lead, if necessary, repair or replace (throttle basic setting).  4) small concrete mixer fuel spray travel is  5) a sense of mass transfer of oxygen failure mixer  6) exhaust recirculation valve  7) concrete mixer truck fuel pressure at the end - check the fuel pressure and fuel pump flow, replacement of components if necessary. Small concrete mixer  8) vacuum leaks mixer 9) air flow sensor - Check sensor and wiring, if necessary, 10) Truck Fuel contamination - Check whether there is water in the fuel and alcohol, if necessary, replace. 11) concrete mixer engine mounting

Please leave a message, our saler will contact you as soon as possible!

  • *Name:
  • *E-mail:
  • Tel:
  • Company:
  • *Country:
  • *Inquiry:
Customer Reviews :
Frequently Questions :

Hot Products

  • Concrete Mixing Drum Concrete Mixing Drum

    1. Concrete mixing tank with Superior performance2. High quality of hydraulic system3. The design of low angle of inclination4. Simple operation and useful application5. Multi types of Chassis Matched

  • Concrete Mixer Truck Concrete Mixer Truck

    1. adopts European modern style2. featuring attractive appearance3. rational structure and stable performance4. different steel materials for different parts of tank body5. Multi types of Chassis Matc......

  • Self-loading Concrete Mixing Station Self-loading Concrete Mixing Station

    1.Equipment Type: Self-loading concrete mixing station2. Model: DS3.53. Productivity: 14m3/hr4. Weight: 7500KG5. Dimension LxWxH: 7.1x2.44x3.3m

Contact Us

Tel: +86-371-86108011
        +86-371-86108022
Fax1: +86-371-86108033
Fax2: +86-371-87575501#812
Mobile: +86-15093371337
Email:sales2@cndasion.com
Address: Dongfeng road, Jinshui zone, Zhengzhou, Henan, China.